Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 DIVYGAYARTI LLC D/B/A/ ROSATI'S PIZZA 		License/Permit #
 BB231
Street Address
118 E BETHEL RD
City/State
 BOURBONNAIS, IL 		ZIP Code
 60914
No. of Risk Factor/Intervention Violations 3
No. of Repeat Risk Factor/Intervention Violations 1
Date 07/30/2019
Time In 02:00 PM
Time Out 04:00 PM
Permit Holder
THAKKAR, RONAK 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized X  
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition   X
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38 X Insects, rodents, & animals not present   X
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54 X Garbage & refuse properly disposed; facilities maintained   X
55 X Physical facilities installed, maintained & clean   X
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: DIVYGAYARTI LLC D/B/A/ ROSATI'S PIZZA Establishment #: BB231
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: QUAT 200-400 Heat: NA °F
CFPM Verification (name, ID#, expiration date):
KARTIKKUMAR PATEL
18224910
08/06/2024 		BRIJECH MADHIWALA
17707958
04/09/2024 		RONAK THAKKAR
21936946
04/10/2028

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
/cooler 36.00°F /cooler 38.00°F /walk-in cooler 40.00°F
/walk-in cooler 50.00°F /walk-in cooler 51.00°F /walk-in cooler 52.00°F
/walk-in cooler 48.00°F /warmer 143.00°F /warmer 145.00°F
/warmer 155.00°F /warmer 161.00°F  

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
16 PF 4-601.11(A): (A) EQUIPMENT FOOD-CONTACT SURFACES and UTENSILS shall be clean to sight and touch.
Bottom of the True freezer has food debris on it. Clean and sanitize. - COS (Correct By: Jul 30, 2019)
22 P 3-501.16(A)(2): (A) Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under §3-501.19, and except as specified under ¶ (B) and in ¶ (C ) of this section, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be maintained: (2) At 5ºC (41ºF) or less.
1. Cheese was found at 51F. 2. Roast beef was found at 51F. 3. Lasagna was found at 48F. These foods were just preped according to Chefs. Will still place food in another cooler at 41F or below just to make sure they cool down properly. Make sure food and cooler are holding proper food temperatures. Will do a follow up within three days. - (Correct By: Aug 2, 2019)
23 PF 3-501.17 (C): (C) A refrigerated, READY-TO-EAT TIME/TEMPERATURE CONTROL FOR SAFETY FOOD ingredient or a portion of a refrigerated, READY-TOEAT, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD that is subsequently combined with additional ingredients or portions of FOOD shall retain the date marking of the earliest-prepared or first- prepared ingredient.
There is no time on the lasagna, pasta, roast beef etc. Make sure all foods have a time and date on them. Will be back within 10 days to make sure this is being done. - Repeat (Correct By: Aug 9, 2019)
38 C 6-202.15 (A) (B) (D): (A) Except as specified in (B), (C), and (E) and under (D) of this section, outer openings of a FOOD ESTABLISHMENT shall be protected against the entry of insects and rodents by: (1) Filling or closing holes and other gaps along floors, walls, and ceilings; (2) Closed, tight-fitting windows; and (3) Solid, self-closing, tight-fitting doors. (B) Paragraph (A) of this section does not apply if a FOOD ESTABLISHMENT opens into a larger structure, such as a mall, airport, or office building, or into an attached structure, such as a porch, and the outer openings from the larger or attached structure are protected against the entry of insects and rodents. (D) Except as specified in (B) and (E) of this section, if the windows or doors of a FOOD ESTABLISHMENT, or of a larger structure within which a FOOD ESTABLISHMENT is located, are kept open for ventilation or other purposes or a TEMPORARY FOOD ESTABLISHMENT is not provided with windows and doors as specified under (A) of this section, the openings shall be protected against the entry of insects and rodents by: (1) 16 mesh to 25.4 mm (16 mesh to 1 inch) screens; (2) Properly designed and installed air curtains to control flying insects; or (3) Other effective means.
Back exit door has air gap at bottom of the door. Make sure there is no air gap at bottom of door. - Repeat (Correct By: Jul 30, 2019)
49 C 4-602.13: NonFOOD-CONTACT SURFACES of EQUIPMENT shall be cleaned at a frequency necessary to preclude accumulation of soil residues.
1. Mop bucket has black debris on it. 2. Interior of fryers and exterior of fryers has grease and food debris on them and in them. Clean thoroughly and maintain. - (Correct By: Jul 30, 2019)
54 C 5-501.13(A): (A)Except as specified in ¶ (B) of this section, receptacles and waste handling units for REFUSE, recyclables, and returnables and for use with materials containing FOOD residue shall be durable, cleanable, insect- and rodent-resistant, leakproof, and nonabsorbent.
Lids open on dumpster. Keep shut when not in use. 5-501.13
There is trash and debris around the dumpster will be back within 10 days to check on dumpster. C - Repeat (Correct By: Aug 9, 2019)
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
1. Filters has grease and debris in them in the grill hood. 2. Floor under fryers has grease and food debris on it. 3. There is grease and food debris on the floor under the stoves. Clean and maintain these areas. - Repeat (Correct By: Jul 30, 2019)
Inspection Comments   MAKE SURE ALL EMPLOYEE'S HAVE AN UPDATED CFPM OR A FOOD HANDLERS CERTIFICATE. WILL DO A FOLLOW UP WITHIN 3 DAYS FOR PRIORITY VIOLATIONS AND 10 DAYS FOR PRIORITY FOUNDATION VIOLATIONS.
HACCP Topic: KEEP ALL COLD FOODS AT 41F OR BELOW TO KEEP IT OUT OF THE TEMPERATURE DANGER ZONE WHERE BACTERIA GROW RAPIDLY.
 

Person In Charge

  JOSE PEREZ 		 

Date:

  07/30/2019
 

Inspector

  Steven Lamb 		 

Follow-up:  Yes   No   Follow-up Date:

08/02/2019